|
Repair Intervals (96+)
Maintainance recomended when you hit the first of either the mileage
or time period below...
5000/4 months
15000/12 Months
30000/24 Months
60000/48 Months
90000/72 Months
5000/4 months
Perform:
-Replace engine oil and oil filter
-Rotate tires (1997 and later)
Inspect:
-Air filter
-Brake linings, discs/drums
-Steering linkage
-Ball joints and boots
-Drive shaft boots (re-torque flange bolts)
-Body/chassis bolts and nuts
Additional maintenance items for special operating conditions:*
-Lubricate steering knuckles (1997 Landcruiser)
-Lubricate propeller shaft (re-torque bolts)(4x4 except RAV4)
*Special Operating Conditions
-Towing a trailer or using a camper or car-top carrier
-Repeated short trips of less than 5 miles below freezing
-Extensive idling or low-speed driving for long distances as in
heavy commercial use such as delivery, taxi or patrol cars
-Operating on rough, muddy or salt-covered roads
-Operating on unpaved or dusty roads
15000/12 Months
Perform
-Replace engine oil and oil filter
-Lubricate steering knuckles (Landcruiser through 199
-Lubricate propeller shaft (re-torque bolts)(4x4 except RAV4)
-Replace air conditioning filter (2000 Avalon XLS)
-Rotate tires (1997 and later)
Inspect
-Exhaust pipes and mountings
-Brake linings, discs/drums, lines, hoses
-Steering linkage
-Steering gear for leakage
-Ball joints and boots
-Drive shaft boots (re-torgue flange bolts)
-Automatic transmission and differential oils
-Transfer case oil
Additional Maintenance Items For Special Operating Conditions:*
-Inspect air filter
-Inspect automatic transmission fluid (2000 model year cars, Sienna,
SUV's and trucks, except Tundra)
-Replace automatic transmission fluid and differential oil, including
limited-slip (all 1996-99 models and 2000 Tundra)
-Replace transfer case oil (4x4 trucks, 4Runner, Landcruiser)
-Inspect body/chassis bolts and nuts
*Special Operating Conditions
-Towing a trailer or using a camper or car-top carrier
-Repeated short trips of less than 5 miles below freezing
-Extensive idling or low-speed driving for long distances as in
heavy commercial use such as delivery, taxi or patrol cars
-Operating on rough, muddy or salt-covered roads
-Operating on unpaved or dusty roads
30000/24 Months
-All 15,000 mile service items plus the following:
Perform
-Replace non-platinum spark plugs**
-Replace air filter
-Replace engine coolant
-Repack rear wheel bearings (Tercel, Paseo)
-Repack front wheel bearings (4x2 Tacoma, T100, Landcruiser, except
4x2 PreRunner)
-Lubricate front driveshaft bushings (4x4 T100, Landcruiser)
-Replace limited-slip differential oil (1998 and later Landcruiser
if equipped with limited slip option)
-Rotate tires (1997 and later)
Inspect
-Drive belts
-Fuel lines and connections, fuel tank vapor vent system hoses,
fuel tank band
-Fuel tank cap gasket
-Supercharger gear oil (Previa)
-Transmission, transfer case and differential oils
Additional Maintenance Items For Special Operating Conditions*
-Replace transmission fluid or oil and differential oil (including
linited-slip)
-Replace transfer case oil (4x4 trucks, 4Runner, Landcruiser)
-Inspect body/chassis bolts and nuts
*Special Operating Conditions
-Towing a trailer or using a camper or car-top carrier
-Repeated short trips of less than 5 miles below freezing
-Extensive idling or low-speed driving for long distances as in
heavy commercial use such as delivery, taxi or patrol cars
-Operating on rough, muddy or salt-covered roads
-Operating on unpaved or dusty roads
**Maintenance service is required under the terms of the Emission
Control Warranty for certain models in certain states
60000/48 Months
All 15,000 and 30,000 mile maintenance items plus the following:
Perform
-Replace platinum spark plugs**
-Replace limited-slip differential oil (Supra, 4x4 RAV4 if equipped
with limited slip option)
Inspect
-Valves (audible inspection), adjust if necessary
-Charcoal canister**
-Rotate tires (1997 and later)
-Drive belts
Additional Maintenance Items For Special Operating Conditions*
-Replace timing belt (if vehicle is so equipped)***
-Replace transmission fluid or oil and differential oils (including
limited-slip)
-Replace transfer case oil (4x4 trucks, 4Runner, Landcruiser)
-Inspect body/chassis bolts and nuts
*Special Operating Conditions
-Towing a trailer or using a camper or car-top carrier
-Repeated short trips of less than 5 miles below freezing
-Extensive idling or low-speed driving for long distances as in
heavy commercial use such as delivery, taxi or patrol cars
-Operating on rough, muddy or salt-covered roads
-Operating on unpaved or dusty roads
**Maintenance service is required under the terms of the Emission
Control Warranty for certain models in certain states
***Recommended at 90,000 miles for 1998 - 2000 models
90000/72 Months
All 15,000, 30,000, and 60,000 mile maintenance items plus the
following:
Perform
-Replace timing belt if vehicle is so equipped (1998 and later)
-Replace iridium spark plugs (Landcruiser)**
Additional Maintenance Items For Special Operating Conditions*
-Replace transmission fluid or oil and differential oils (including
limited-slip)
-Replace transfer case oil (4x4 models)
*Special Operating Conditions
-Towing a trailer or using a camper or car-top carrier
-Repeated short trips of less than 5 miles below freezing
-Extensive idling or low-speed driving for long distances as in
heavy commercial use such as delivery, taxi or patrol cars
-Operating on rough, muddy or salt-covered roads
-Operating on unpaved or dusty roads
**Maintenance service is required under the terms of the Emission
Control Warranty for certain models in certain states
|
